Flight Hall construction builds the Agrotel Austrian company based in Bavaria in mobile construction in Duschanbe Neuhaus / Inn, September 2009 – in the 4,500 kilometres as the crow flies of away Dushanbe an easy construction Hall covered with a tarpaulin. The 2,600 m2 large buildings used as Terminal is used for Assembly and maintenance work on aircraft. Agrotel GmbH company was commissioned to build a hangar in the high mountain country Tajikistan in around 543.000 residents large capital Dushanbe at the hangar. To, parts of the Hall in a 15-day trip with several trucks over the Turkey be moved to Central Asia in September. From early October until the end of December, the Hall is set up and January 2010 in operation. The Assembly is carried out proprietary professional installers that fit the frame parts on the ground. Then, the parts in bundles are pulled up and attached to anchor profiles. Then the Hall Panel on the roof is raised, spread along the first edge and firmly braced.
Finally the gable walls are set up and with a double gate system, in which the Space requirements of the rear part are taken into account, as well as other required devices equipped. The hangar used military transport aircraft such as the Airbus A400M or prop transport aircraft Transall C-160 type to Assembly and maintenance work on wide-body aircraft such as the Airbus A310. The construction system allows extreme spans through flexible Hall solution to build halls very wide and spacious. 51 times the aircraft hangar, a second inner skin-clad, with the mass 51 metres and an inside height of 19 meters, provides effective protection for aircraft and their maintenance facilities. The load-bearing structure of the Hall consists of timber trusses with square, hot-dip galvanized steel pipes, which are anchored to concrete foundations with heavy load anchors. Round tubes are used as secondary design.
The steel truss are measured precisely for the local wind and snow loads of Duschanbes. So that can be used in the winter months, a heating hose with one is around halfway down hall 120 centimetres in diameter mounted. Agrotel was founded in 1987 by Cyriak Laner. Through continuous improvement and new ideas, the company now offers a complete range of textile products for the agriculture. In addition to roll and control techniques for Seitenluftungs systems, textile door solutions for the agricultural sector and comfort products for livestock, and bio-gas components and Hall systems were integrated.